Product ID:GLYPTAL AIR DRY ENAMEL 1201
MSDS Date:05/28/1996
FSC:5970
NIIN:00-583-0401
MSDS Number: BSRYG

GLYPTAL INC

305 EASTERN AVE
CHELSEA, MA 02150-3344
US

Emergency Phone: 617-884-6918

Info Phone: 617-884-6918

Cage: 65313

THE SMITH GROUP INC.

PHILADELPHIA, PA 19124-3893 US

Telephone: 215-743-8200

Cage: 2B613

XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9495

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VARNISH MAKERS & PAINTER NAPHTHA

CAS: 8030-30-6

IRON OXIDE

CAS: 1309-38-2

RTECS: OM4800000

HYDRATED MAGNESIUM SILICATE (TALC, CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: MW2700000

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST 9394

STODDARD SOLVENT,

CAS: 64741-41-9

ALKYD RESIN (MANUFACTURER STATES NON-HAZARDOUS)

LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN AND EYE CONTACT:PRIMARY
IRRITATION. CHRONIC: XYLENE CONTAINED IN THIS MATERIAL HAS BEEN
FOUND TO CAUSE THE FOLLOWING EFFECTS IN LABORATORY ANIMALS: ANEMIA,
LIVER ABNORMALITIES, LIVER AND E YE DAMAGE. REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OVEREXPOSURE TO XYLENE WITH PERMANENT BRAIN
AND NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS OF THIS PRODUCT
ARE REPORTED CARCINOGENS IN A/C WITH OSHA, NTP, IARC OR NIOSH.
Effects of Overexposure:HEADACHE, NAUSEA, DIZZINESS, CONFUSION,
IRRITABILITY.
Medical Cond Aggravated by Exposure:PRE-EXISTING LIVER AND KIDNEY
DISORDERS MAY BE AGGREVATED BY EXPOSURE TO XYLENE.

First Aid:INHALATION-REMOVE TO FRESH AIR. ADMINISTER ARTIFICIAL
RESPIRATION OR OXYGEN IF BREATHING IS DIFFICULT. SKIN-WASH AFFETCED
AREA WITH SOAP AND WATER. REMOVE AND LAUNDER CONTAMINATED CLOTHING.
CONSULT A PHYSICIAN IF IRRITATION PERSISTS. EYES-FLUSH IMMEDIATELY
WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN. TAKE TO PHYSICIAN
FOR MEDICAL TREATMENT. INGESTION-CALL A PHYSICIAN IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:=22.2C, 72.F
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, BUT MAY BE USED TO
COOL CONTAINERS EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD
WEAR SELF- CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:PRESSURE MAY BUILD UP IN CLOSED
CONTAINERS THAT ARE EXPOSED TO HEAT.SOLVENT VAPORS ARE HEAVIER THAN
AIR, MAY TRAVEL TO DISTANT IGNITION SOURCE AND "FLASH BACK".

Spill Release Procedures:PROVIDE ADEQUATE VENTILATION. REMOVE ALL
POSSIBLE IGNITION SOURCES. ABSORB AND DISPOSE OF SPILL USING
NON-SPARKING TOOLS. ELIMINATE ALL SOURCES OF IGNITION. EVACUATE
UNPROTECTED PERSONNEL. WATER SPRAY MAY BE USED. TO CONTAIN
RUN-OFF, COVERWITH AN ABSORBENT & PLACE IN CONTAINERS FOR PROPER
DISPOSAL. FLUSH AREA WITH WATER TO REMOVE RESIDUE.

Handling and Storage Precautions:STORE IN COOL DRY PLACE AWAY FROM
HEAT, SPARKS, AND OPEN FLAME. KEEP CONTAINERS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE. OUTSIDE OR DETACHED STORAGE PREFERRED.
Other Precautions:INSIDE STORAGE SHOULD BE IN A STANDARD FLAMMABLE
LIQUID STOREROOM OR CABINET. METAL CONTAINERS SHOULD BE GROUNDED
WHEN TRASFERRING MATERIAL FROM ONE CONTAINER TO ANOTHER. DO NOT
REUSE PRODUCT CONTAINE R FOR ANY PURPOSE.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS USE BUREAU OF MINES
APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE
PARTICULATESOF OVERSPRAY. INDOORS,WHERE VENTILATION IS
INADEQUATE,USE CHEMICAL-MECHANICAL RE SPIRATOR FOR BOTH PARTICULATE
AND VAPOR.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION AS
REQUIRED TO MAINTAIN EXPOSURE LEVELS.
Protective Gloves:RECOMMENDED IF SKIN CONTACT LIKELY.
Eye Protection:CHEMICAL SPLASH GOGGLES RECOMMENDED.
Other Protective Equipment:RECOMMENDED AS NEEDED TO AVOID CONTACT.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health

HCC:F2
NRC/State Lic Num:NONE
Boiling Pt:=121.C, 249.8F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:5.79 MM
Vapor Density:>1
Spec Gravity:1.2
VOC Grams/Liter:3.98
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID W/PAINT ODOR
Percent Volatiles by Volume:56.5

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND BASES.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NORMAL PRODUCTS OF INCOMPLETE
COMBUSTION.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DISPOSE OF USING AN APPROVED INCINERATION
PROCESS OR I/A/W FEDERAL, STATE & LOCAL REGULATIONS REGARDING
HEALTH & POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.